Recent content by cerozg

Thought it might be helpful. According to renault data: F4R730(clio 172) / F4R830(clio 197) Valve lift: inlet 11mm / 11.6mm exhaust 10mm / 10.6mm Dephaser angle: 16 degrees /...

Thanks. I have another jc5 for parts. If this doesnt match i will contact you.

Gearbox reconditioning goes on. I ordered new washer under the circlip. There is thicker 2.5mm and thinner 1.8mm washer. Disassembled gear shaft (gear pyramide). Shaft is hollow so oil is going through it and lubricate gear bushes and synchrons. It was dirty from inside and between bushes and...

This is original renault plate. Where did you get it?

I had standard JB3 GT Turbo gearbox on my modified R5. 25 years old box with no problems. Then I decided to use JC5 from clio 172 because of better gear ratios. I disassembled it to check if box is in good condition. Found worn 1-2 gear fork and worn diff circlip and washer. So it would be...

Yes, on ebay. http://www.ebay.ie/itm/Gearbox-renfort-Clio-Williams-JC5-JB3-16V-F7P-F7R-2L-/180853487230?hash=item2a1bb5367e:m:mpnsRuqYWZgR31NjsTxyjBQ But I wanted original renault plate. Original renault four bolt plate is not available as far as I know.

Thank you for your thorugh answer. Today I received the same info from another source. So that is it, part is not available as separate item, only with differential. I will have to find another solution. This is a common problem on clio 172 JC5 gearboxes. I think there are two main causes for...

No answer. It shows a lot about quality of this forum and about technical expertise of its members.

I am looking for jc5-130 differential reinforcement plate. The one with four bolts. I wanted to order it from renault dealership, but they cant find gearbox model that has plate with bolts instead of circlip. I told them it is jc5-130 gearbox but they insist there is no jc5 gearbox with plate...

I have a problem with F7P engine. It was in very bad condition: worn pistons and cylinders, lots of rust in engine coolant system, engine internals full of sludge... I fully recondicioned the engine; everything cleaned and thoroughly inspected, all oil passages and coolant passages cleaned, oil...